HOME | FORUM

Periodic Maintenance Chart - 800 Drifter

DOWNLOADABLE PDF

This chart is Kawasaki's PM schedule. You should verify these frequencies for yourself. This chart is offered for reference and may not be all-inclusive, accurate, nor up-to-date.

PM

TIME

600mi

1000km

4000mi

6000km

7500mi

12000km

12000mi

18000km

15000mi

24000km

20000mi

30000km

24000mi

36000km
Idle Speed - adjust 6 MonthsXXX XXXX
Spark Plugs   Clean & Gap *  XXXXXX
Valve Clearance Check *    X X X
Air Suction Valve *  XXXXXX
Air Cleaner Element *#   X X X
Throttle Grip Play - Check* X X X X
Engine Oil   Change #6 MonthsXXXXXXX
Oil Filter   Replace X X X X
Oil Screen - Clean X  X X X
Radiator Hoses, connections   Check *  X      
Coolant   Change2 Years    X  
Final Gear Case oil Level   Check   X X X
Final Gear Case oil Level   Change X     X
Propeller Shaft Lube   X   X
Clutch Adjust XXXXXXX
Drive Chain Wear - Check * #    XXXXXX
Drive Chain - Lubricate # 600 mm       
Drive Chain slack - check * # 1000 km       
Brake lining or pad wear   Check * #  XXXXXX
Brake/Clutch hose   connections *  XXXXXX
Fuel Hoses, connections *  XXXXXX
Brake Level Fluid Check *MonthXXXXXXX
Brake Fluid Change2 Years    X  
Brake master cylinder cup dust seal - replace4 Years       
Caliper piston seal and dust seal - replace4 Years        
Brake light switch - check* XXXXXXX
Steering check * XXXXXXX
Steering stem bearing   lubricate *2 Years    X  
Front Fork Oil   Change2 Years    X  
Rear Shock oil leak check *   X X X
Front Fork Oil leak check *   X X X
Tire Wear  XXXXXX
Spoke tightness and rim runout XXXXXXX
Swingarm pivot   lubricate   X   X
General Lubrication   X X X
Fastener tightness X X X X
PM        
PM        

#: Service more frequently when operating in severe conditions; dusty, wet, muddy, high speed, or frequent starting/ stopping

+: For higher odometer readings, repeat at the frequency interval established here.

*: Replace, add, adjust, clean or torque if necessary

 


Email to Webmaster
Your comments are always welcome.



Web site design by Saftek.


Copyright © , Saftek Inc.


Duplication of any element of this
site without the express permission
of Saftek, Inc. is a violation of
law and is prohibited.

 

Not affiliated with Kawasaki. Kawasaki, Vulcan and Drifter are trademarks of Kawasaki.