GUEST? Registration opens up many more resources which are not available to guests. Registration is free, we never sell or give others access to your information.
Posted by Troll
- March 13, 2013, 11:18:46 AMAfter the bike was crashed, did the trans shift ok, or did no one check that? Crash damage is usually more than just cosmetic. The positive neutral finder is a blessing, but it does have a drawback. The bike will not shift past 1st. gear if it's not moving. If the clutch disengages enough to get 1st. gear, then a short ride seems in order. If the trans. won't shift, it might be time to inform your insurance company. I bought mine with a broken transmission, and it's a very expensive proposition to fix. Cases must be split.....In the insurance game, they call this hidden damage...just hope you didn't sign off on a settlement. Good luck, you might need it.
Posted by 49Reo
- March 13, 2013, 09:54:59 AMMan, talk about bad luck! You should be able to work the bike up to 5th gear just by rocking it back and forth with the engine shut off, and without using the clutch. If it shifts from neutral to first okay, and back to neutral, but not up to second, it sounds internal. That being said, I have never been inside one of these bikes so I expect there are others on here (like Troll for instance) who could help you out.
Good luck with it, and keep us poster.
Regards,
49Reo
Posted by BigUgly
- March 13, 2013, 09:47:55 AMThanks for the reply John.
Gonna rebled it in about 2 hours. I Just changed the oil two days before I wrecked. Do you thing the oil would go bad with only 100 or so miles on it even though it set for 5 months? I used Royal Purple.
Big Ugly
Posted by John Hopkins
- March 13, 2013, 09:35:31 AMFirst things first, are you sure the clutch has been bled properly..sometimes you can get air trapped in the top banjo nut at the master cylinder and you have to crack the nut and bleed it.
if the hydrolics are all good the next thing is the plates can stick together if the bike has not been used for five months..
an oil change is the next thing to do.
John.
Posted by BigUgly
- March 12, 2013, 22:59:59 PMHello All.
Been a long time since I have posted. The last year has been a whooper. Had surgery on my left elbow(work injury). Then the day after I was released to go back to work I was cut off by a cager and wrecked my Drifter. Thank God that the handle bars and the hwybar absorbed all the damage. I broke my right shoulder which I'll be having shoulder replacement surgery sometime at the end of May. I have to wait until I'm off my blood thinners from my second Heart surgery in three years, that I had in Febuaray.
As you can see I have had a great fun adventure the last twelve months.
But now to the reason I'm posting. My doctor who also rides has released me to ride until my shoulder surgery in May. As I was finishing up the last few repairs to my bike, I had no clutch pressure. After 3 days of bleeding the line my wonderful wife found the small leak around the tit on the clutch switch. So I ordered a new Clutch Master Cylinder. I replaced it tonight and bleed the line until I had fresh Dot 4 fluid and no air.
The bike starts up and runs strong. But, I only have Neutral and 1st gear. The clutch will not go into 2nd no matter what. even pushed her out into the alley and tried to do it while I was moving but no luck. I read a post about the plates sticking, and since my bike hasn't been ran since September 30th I ran the bike for about 20-30 minutes but still no second gear. Tried rocking it back and forth, with the same results.
Not sure what I need to check next. Any suggestions for you guys would be greatly appreciated.
My Drifter is a 2001 1500.
Thanks
Allan
AKA: Big Ugly