We limit access by GUESTS to protect our members from spam, hacks and trolls. Please register to gain access to all our resources.
Posted by Fab
- June 30, 2025, 14:20:21 PMQuote from: Troll on April 14, 2025, 07:15:18 AMI just realized that I forgot to post an update on this.The "choke" cable pulls a cam on the throttle body that raises the idle slightly. If used in conjunction with a working set of idle solenoids, it will raise the idle enough to prevent an over rich cold mixture, and the abrupt drop in idle speed that occurs when the idle solenoids stop.
The cam pulled by the choke cable was hitting the end side of a small screw.
Apparently the screw is used to adjust the idle rise by pulling the choke cable all the way out.
The tighter the screw, the more its end sticks out and reduces the cam clearance.
In my case, it was screwed all the way in and thus completely prevented the cam from raising the idle at all.
The screw is mounted horizontally with the head facing the left side of the bike. In addition, there is a small spring between the screw head and the metal plate, probably to hold the screw in place.
I had to lift the tank, use a thin screwdriver from the left side, and loosen the screw a quarter turn at a time until the choke cable started working as intended.
This is a view from the right side of the bike:
And this is a view from under the tank on the left side:
Posted by Troll
- April 14, 2025, 07:15:18 AMThe "choke" cable pulls a cam on the throttle body that raises the idle slightly. If used in conjunction with a working set of idle solenoids, it will raise the idle enough to prevent an over rich cold mixture, and the abrupt drop in idle speed that occurs when the idle solenoids stop.
Posted by Fab
- April 14, 2025, 03:04:27 AMThanks Paul,
QuoteIt's spring here in Italy, so I can't test it in cold whether at the moment.I use the choke in winter (in Australia) .
Whenever I use it , it makes for a fast idle , unmistakably !
If I understand correctly, fast idling by pulling the choke should happen regardless of the outside temperature, right?
If so, I'll have to have it checked by a mechanic sooner or later.
Posted by drifter-paul
- April 14, 2025, 02:35:59 AMI use the choke in winter (in Australia) .
Whenever I use it , it makes for a fast idle , unmistakably ! I push it in after a minute warm up - earlier can cause a stall or stutter .
Posted by Fab
- April 14, 2025, 02:02:47 AMReading old posts on this forum, I realized that the choke knob on the 1500 is actually a fast idle control.
From the user manual:
QuoteDoes this mean that the fast idle control only works in cold weather or at high altitude, or should it raise the idle regardless of temperature and altitude? I ask because it is no longer cold here, and pulling the choke knob does not seem to change the idle at all on my 1500, either when the bike is cold or when it is warm.Pull the choke knob all the way out if the engine is hard to start in cold weather or at high altitudes, and then return the chock knob all the way back when the engine is warmed up enough to idle without using the choke.
Thank you.